1. Attachments are working again! Check out this thread for more details and to report any other bugs.

suspicious noise

Discussion in 'Gen 2 Prius Care, Maintenance and Troubleshooting' started by blackmasked, Nov 30, 2015.

  1. blackmasked

    blackmasked Junior Member

    Joined:
    Nov 30, 2015
    7
    0
    0
    Location:
    London, UK
    Vehicle:
    2007 Prius
    Model:
    N/A
    Hi there
    I have recently purchased a 2007 Gen 2 Prius and sometimes it emits a very annoying squeak. It occurs when the car is stationary, with the brake pedal fully depressed. When inside the vehicle it seems to be coming from behind the glove box. When on the outside and facing the car it seems to be coming from below / behind the electric motor. I have made a recording of it with the noise in question being audible for a couple of seconds at 0:13, and then again at 0:22 until the end. It could be nothing I guess, but this is my first hybrid and I am not too sure what is perfectly normal and what is not.



    Any suggestions?
     
  2. valde3

    valde3 Senior Member

    Joined:
    Jun 28, 2014
    2,002
    745
    0
    Location:
    Finland
    Vehicle:
    2004 Prius
    Do you mean the buzzing noise from brake pressure pump? It’s normal. It pressurizes brake pressure accumulator, where pressure can be taken to apply brakes when needed. You do get used to the sound.
     
  3. tanglefoot

    tanglefoot Whee!

    Joined:
    Mar 27, 2007
    625
    188
    0
    Location:
    Colorado
    Vehicle:
    2007 Prius
    The rattlesnake-like sound is the brake pump but you're probably referring to that rhythmic sound like a squirrel jumping on an old car or something. That's a weird one--I've never heard it. It doesn't sound normal. Is the climate control blower on? If so, there could be something interfering with its rotation? You could try removing the cabin air filter and inspecting. Open the lower front passenger glovebox, squeeze the back of the sides to release the holding pins from the dash, undo the little plastic strut on the R-side and let the glove box lower completely. Then locate the rectangular, white plastic panel with two latches, hold the latches open and pull the panel out toward you. Then you can inspect the blower (and change/clean the cabin filter).

    Oh, does it stop when you release the brake pedal? If so, it's probably not the blower motor. Maybe someone else knows...
     
  4. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    107,571
    48,862
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    welcome! is it the brake honking sound?
     
  5. blackmasked

    blackmasked Junior Member

    Joined:
    Nov 30, 2015
    7
    0
    0
    Location:
    London, UK
    Vehicle:
    2007 Prius
    Model:
    N/A
    I was referring to the 'squirrel' sound, not the buzzing sound.
    It sounds like a rotating part that rubs against something once per revolution.

    As soon as I take the foot off the brake pedal and the car starts to move, the noise goes away.
    Air con was off when I made the recording, but I think I will still remove the glove box and see if I can get a bit closer to the source of the noise.
     
  6. blackmasked

    blackmasked Junior Member

    Joined:
    Nov 30, 2015
    7
    0
    0
    Location:
    London, UK
    Vehicle:
    2007 Prius
    Model:
    N/A
    I have done a bit of research and others describe it as honking, squeaking even barking ;]
    Have you clicked on the Vocaroo link in my original post?

     
    #6 blackmasked, Nov 30, 2015
    Last edited: Nov 30, 2015
  7. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    107,571
    48,862
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    unfortunately, i don't have flash player on my mac.
     
  8. goldfinger

    goldfinger Active Member

    Joined:
    Mar 12, 2012
    535
    402
    0
    Location:
    Buffalo
    Vehicle:
    2016 Prius
    Model:
    Three
    Does it make this sound at different fan speeds? The fan never turns off completely. Try a higher fan speed.
     
  9. jdenenberg

    jdenenberg EE Professor

    Joined:
    Nov 21, 2005
    3,831
    1,825
    1
    Location:
    Trumbull, CT
    Vehicle:
    2020 Prius
    Model:
    LE AWD-e
    The clicking is the brake accumulator pump.

    JeffD
     
  10. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    107,571
    48,862
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    oh boy, that's expensive. i would just ignore it.
     
  11. The Electric Me

    The Electric Me Go Speed Go!

    Joined:
    May 22, 2009
    9,083
    5,795
    0
    Location:
    Undisclosed Location
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    Honks, squeaks, buzzing and barking, rattle-snakes and squirrels?

    Maybe you need an exorcist.
     
  12. blackmasked

    blackmasked Junior Member

    Joined:
    Nov 30, 2015
    7
    0
    0
    Location:
    London, UK
    Vehicle:
    2007 Prius
    Model:
    N/A
    Thanks for your responses guys.
    I could be wrong but what's in the attached TSB sounds very familiar to the problems I am experiencing.
     

    Attached Files:

  13. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    107,571
    48,862
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    that's it!
     
  14. JC91006

    JC91006 Senior Member

    Joined:
    Nov 10, 2013
    16,464
    8,377
    0
    Location:
    Los Angeles, CA
    Vehicle:
    2008 Prius
    Model:
    II
    You're a bit late for the warranty though
     
  15. blackmasked

    blackmasked Junior Member

    Joined:
    Nov 30, 2015
    7
    0
    0
    Location:
    London, UK
    Vehicle:
    2007 Prius
    Model:
    N/A
    I got lucky I guess as the car came with 3 month warranty, and the brake actuator a.k.a. brake booster actuator pump assembly has been replaced FOC by the dealership.