1. Attachments are working again! Check out this thread for more details and to report any other bugs.

12v battery issue?

Discussion in 'Gen 3 Prius Care, Maintenance & Troubleshooting' started by Earlybird2021, Feb 15, 2021.

  1. Earlybird2021

    Earlybird2021 New Member

    Joined:
    Feb 15, 2021
    1
    0
    0
    Location:
    Ellensburg, WA
    Vehicle:
    2015 Prius
    Model:
    Four
    I have a 2015 Prius with about 110K miles on it. It has been a trouble-free dream. It has not been driven as regularly since the pandemic, and we have been experiencing a few weeks of pretty cold temps (for us; down into the teens at night, high 20s during the day).

    Last week, the car would not start (the dash lights did turn on, but it would not start). We put a batter charger on it and it started right up after a few minutes. I drove it down the block and back, then for the rest of the week, I started it every or every-other day. Today it is completely dead again - dash lights won't even respond this time. I think I need to just replace the 12v battery.

    I also need to replace my key fob battery - but cannot find the correct type of CR1632 batter at the 3 places I've looked in town. Frustrating, but I don't think this is the source of the problem.

    So my issue is - I live 40 miles away from the nearest Toyota dealer where I normally do all my maintenance. I plan to take it there to get the 12v battery replaced. Assuming I can get it charged up again, is it okay to drive that 40 miles (about 40 minutes, highway speeds of 70mph, up and down hills) or is this dangerous? Is the car at risk of stalling during a drive with a sickly 12v battery?

    Thanks for the advice.
     
  2. rjparker

    rjparker Tu Humilde Sirviente

    Joined:
    Jun 6, 2008
    7,474
    4,373
    7
    Location:
    Texas Hill Country
    Vehicle:
    2012 Prius v wagon
    Model:
    Three
    "It has not been driven as regularly since the pandemic," Is the problem. Go to an auto supply and have the battery load tested. 90% you need a new one. Then keep it charged.

     
    jerrymildred likes this.
  3. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    107,571
    48,862
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    once started, the inverter takes care of the 12v needs. you'll be fine.

    you can also jump start from another car, or a lithium jump pack
     
  4. sam spade 2

    sam spade 2 Senior Member

    Joined:
    Mar 31, 2018
    7,035
    2,780
    0
    Location:
    USA
    Vehicle:
    2017 Prius c
    Model:
    Four
    No guarantee but it likely will be fine.
    Call them first to be sure that they have a battery in stock......and so they can have it charged up before you get there.

    There is really no "need" to have this done at a dealership.
    Many auto parts stores might do it too.
    Make some calls......and save yourself several hours. Maybe some $$$ too.

    Wherever you get the new battery, it MUST be fully charged before install.......or immediately after.
    You can't depend on the car to charge it up if it's not close to start with.
     
  5. jerrymildred

    jerrymildred Senior Member

    Joined:
    Oct 28, 2016
    11,490
    14,095
    0
    Location:
    Tampa, FL
    Vehicle:
    2017 Prius
    Model:
    Two
    That'll kill a 12V in no time. It takes a LOT more than just a drive down the block to recharge what bled off sitting idle and got used starting up the computers and closing the relays. Short drives like that will just pull the battery lower and lower.

    Most any auto parts store should have a replacement battery, although the one from Toyota is a fantastic battery. And then do what @rjparker recommended and keep it on a charger till you're ready to drive normally.

    The fob battery is a CR2032 and is available anywhere batteries are sold. The 1632 is a little smaller in diameter. I wonder if someone put in the wrong one at some point. Battery Cross Reference Chart copy.png


    https://parts.olathetoyota.com/blog/9087/how-to-change-prius-key-battery
     
  6. Mendel Leisk

    Mendel Leisk Senior Member

    Joined:
    Oct 17, 2010
    54,474
    38,105
    80
    Location:
    Greater Vancouver, British Columbia, Canada
    Vehicle:
    2010 Prius
    Model:
    Touring
    Measure voltage first thing in the morning with a digital meter, post the result. Better:

    Most automotive retailers selling 12 volt batteries will have a pro-level electronic load tester, can assess the battery’s viability, usually for free.

    You can do the test yourself with a pro-sumer level tester, like Solar BA9.

    A healthy battery will show voltage at least 12.5, and Cold Cranking Amps at least higher than spec, typically 50+ or more.
     
  7. sam spade 2

    sam spade 2 Senior Member

    Joined:
    Mar 31, 2018
    7,035
    2,780
    0
    Location:
    USA
    Vehicle:
    2017 Prius c
    Model:
    Four
    And often come out with the WRONG answer.
    :(
     
  8. NT Ram

    NT Ram Junior Member

    Joined:
    Feb 12, 2016
    1
    1
    0
    Location:
    Amsterdam
    Vehicle:
    2010 Prius
    Model:
    N/A
    You linked to a Gen 2 instructions. Gen 3 is a CR1632 (as you posted yourself in Battery for Gen 3 remote | PriusChat )
     
    jerrymildred likes this.
  9. jerrymildred

    jerrymildred Senior Member

    Joined:
    Oct 28, 2016
    11,490
    14,095
    0
    Location:
    Tampa, FL
    Vehicle:
    2017 Prius
    Model:
    Two
    Thanks.

    I stand corrected. I should have checked the manual.

    Screen Shot 2021-03-30 at 8.52.42 AM.png