1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Problem after egr cooler cleaning.

Discussion in 'Gen 3 Prius Care, Maintenance & Troubleshooting' started by nathenvan, Oct 11, 2021.

Page 3 of 3
  1. nathenvan

    nathenvan Junior Member

    Joined:
    Nov 9, 2011
    45
    15
    0
    Location:
    Delaware
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    Update.
    I think I found the problem. The air intake filter was clogged so I replaced it with a new one. Now the car drives much smoother without hesitation. Filter still looks new but I guess after six months it is time for a new one. thank you all for your help.
     
    #41 nathenvan, Nov 2, 2021
  2. OptimusPriustus

    OptimusPriustus Active Member

    Joined:
    Jul 31, 2021
    308
    131
    1
    Location:
    Finland
    Vehicle:
    2010 Prius
    Model:
    N/A
    Filter cannot get clogged that badly in 6months. But whatever it was it’s good to hear car now running fine
     
    #42 OptimusPriustus, Nov 4, 2021
  3. nathenvan

    nathenvan Junior Member

    Joined:
    Nov 9, 2011
    45
    15
    0
    Location:
    Delaware
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    You are correct, the problem is back although drivable. I feel like the throttle may be bad. It sounds like it does not open big enough for air to come in when I step on the gas at stops.
     
    #43 nathenvan, Nov 5, 2021
  4. Paladain55

    Paladain55 Active Member

    Joined:
    Oct 20, 2021
    378
    143
    0
    Location:
    The South
    Vehicle:
    2010 Prius
    Model:
    Two
    There is also a built in prefilter in that box too above the actual filter.
     
    #44 Paladain55, Nov 5, 2021
  5. ChapmanF

    ChapmanF Senior Member

    Joined:
    Mar 30, 2008
    23,936
    15,560
    0
    Location:
    Indiana, USA
    Vehicle:
    2010 Prius
    Model:
    IV
    In the airflow direction that would be a "postfilter"; according to Toyota it is an activated carbon pad for absorbing vapors. It isn't replaceable (except with that whole top of the box). Being in that "postfilter" position, it isn't likely to need any attention.
     
    #45 ChapmanF, Nov 5, 2021
    CR94, Paladain55 and Mendel Leisk like this.
  6. FED

    FED Junior Member

    Joined:
    May 15, 2021
    9
    1
    0
    Location:
    argetina
    Vehicle:
    2012 Prius
    Model:
    III
    after reading your post i have a similar issue of engine noise but i dont see you solved the problem. Did you but not posted? thanks.
     
    #46 FED, Feb 22, 2022
  7. nathenvan

    nathenvan Junior Member

    Joined:
    Nov 9, 2011
    45
    15
    0
    Location:
    Delaware
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    I did finally figured out what the problem was. The first time I cleaned the throttle body I was being extra careful and only spray cleaner on the cloth and wiped it down. I did also sprayed on the toothbrush and carefully brushing it cleaned just as I have seen on some YouTube videos. Imo this apparently did not cleaned the throttle body well ( some got into the crevices) and caused it to open with hesitation when acceleration is applied. On the second try I covered the connector and went to town with the throttle body cleaner. Sprayed a good amount and cleaned up with a cloth. Car has been running great since. Hope that helps.
     
    #47 nathenvan, Feb 27, 2022
    ASRDogman likes this.
(You must log in or sign up to post here.)
Page 3 of 3