About to replace by Rear calipers on my 2010, do I need to disable ABS?

Discussion in 'Gen 3 Prius Care, Maintenance & Troubleshooting' started by TarAlacrin, Dec 3, 2025 at 6:17 PM.

  1. TarAlacrin

    TarAlacrin New Member

    Joined:
    Yesterday
    3
    0
    0
    Location:
    Michigan
    Vehicle:
    2010 Prius
    Model:
    III
    My calipers are starting to go and I'm looking to replace them myself. I was talking to my mechanic and he mentioned that if I decided to replace my calipers myself that I should be sure to disable the ABS system first otherwise the piston will shoot out and then its bad and I'll have to get it towed, he says that he learned that from experience when he used to work on hybrids at the dealership.

    But I've been poking around on the internet and I haven't seen anything about this issue, nor any advice on how to disable the ABS easily. Is this necessary? And if so, how do I disable the ABS?
     
  2. PriusCamper

    PriusCamper Senior Member

    Joined:
    Mar 3, 2012
    12,728
    5,146
    0
    Location:
    Pacific Northwest, USA
    Vehicle:
    2007 Prius
    Model:
    Two
    It's as easy as disconnecting 12v battery because the brake booster pump runs even when the car is turned off. But more importantly why do you think your "calipers are starting to go?" They aren't exactly a wear and tear part? Is it perhaps because they're making creaking sounds? Because I had that problem and when I replaced my original brake pads at 287K miles I simply greased the pins the calipers move on and problem solved, no need to do anything else.
     
  3. TarAlacrin

    TarAlacrin New Member

    Joined:
    Yesterday
    3
    0
    0
    Location:
    Michigan
    Vehicle:
    2010 Prius
    Model:
    III
    My mechanic said that the caliper was leaking and that's why it needed a replacement. Is this a fake diagnosis? I generally trust these guys.
     
  4. indel

    indel Member

    Joined:
    Apr 1, 2024
    72
    25
    1
    Location:
    Northwest Indiana
    Vehicle:
    2012 Prius
    Model:
    Two
    Agree with @PriusCamper. Unless the calipers are fully rusted and disintegrating because you live in extreme climate, you should not need to replace them. Replace the pads, and lube the pins. Use silicone based lubricant only, on the pins, such as the NAPA Sil-Glyde (https://www.napaonline.com/en/p/BK_7651351?srsltid=AfmBOopHcuknQ1YHOHlm3P9UfWQzlJQDDWASPQO_BqubbyFyPFnVDtTJ)

    Edit: Of course, you might find that the rubber boots on the calipers are worn/leaking. At that point it's a tossup between rebuilding the caliper vs buying a new one. Nine out of ten times, I replace the caliper when this happens.
     
    #4 indel, Dec 3, 2025 at 9:32 PM
    Last edited: Dec 3, 2025 at 10:44 PM
    PriusCamper likes this.
  5. TarAlacrin

    TarAlacrin New Member

    Joined:
    Yesterday
    3
    0
    0
    Location:
    Michigan
    Vehicle:
    2010 Prius
    Model:
    III
    I do live in Michigan, land of rust and salt and potholes, and am a bit rough on this car. So what would be causing them to leak brake fluid? I'll take a look at it this week but is that something that an unlubed pin would fix?
     
  6. ASRDogman

    ASRDogman Senior Member

    Joined:
    May 29, 2018
    7,570
    3,904
    0
    Location:
    Florida
    Vehicle:
    2010 Prius
    Model:
    Two
    That could happen on the REAR calipers. But it's NOT the abs.
    If you open the drivers door, the brakes will pump up the fluid and push the pucks out.

    Just don't open the door while working on the rear brakes.

    Unless the pistons/pucks, are frozen, there is NO reason to replace them.

     
    PriusCamper likes this.