1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Battery Knowledge

Discussion in 'Gen 2 Prius Care, Maintenance and Troubleshooting' started by Actual Mileage, Sep 10, 2009.

?
  1. What's an auxilary battery?

    4.8%
  2. Yes of course, this was detailed on PriusChat in 1999 after we took apart the first prototype.

    81.0%
  3. I didn't know there would be math involved.

    4.8%
  4. Joe Wilson says your battery is faking.

    14.3%
Multiple votes are allowed.
  1. Actual Mileage

    Joined:
    Aug 10, 2006
    153
    2
    0
    Location:
    Portland. Maine
    Vehicle:
    Other Hybrid
    Model:
    N/A
    I have searched the site and read about all types of battery issues for the past couple hours – but some major points seem unaddressed. I am just to consolidate knowledge here.
    1. I read that the general life expectancy for the auxiliary battery is 3 - 5 years. Is this commonly accepted knowledge?
    2. When I bought the Prius, it was implied that the batteries would last forever. I don’t remember having been told that this battery would eventually need replacing.
    3. I see where many have replaced these with other than OEM parts. Is this a risk?

    My specific situation –
    I have a 2006 with 40,000 miles.
    My car has been dead several times (maybe 4) in the past 6 months.
    Nothing happens when I try to start the car; I cannot open the back hatch; once jumped, I get a warning about the parking brake and moving the car to a flat surface.
    This morning after starting, the battery meter showed 2 purple bars, which then switched to fully green within a mile and then back to the usual 4 or 5 blue bars.
    I have an after market stereo - perhaps it may be connected to the battery in a way that runs it down after turning off the car. Is that possible?
     
  2. jayman

    jayman Senior Member

    Joined:
    Oct 21, 2004
    13,439
    639
    0
    Location:
    Winnipeg Manitoba
    Vehicle:
    2004 Prius
    Ok, first of all, the 12 vdc battery is located at the right rear of the car, not in the front

    [​IMG]

    The thing I outlined in blue is the battery vent tube provision.

    Yes, 3-5 is a reasonable life expectancy. The NiMH traction battery should last much longer, in taxi service the traction battery will go beyond 300,000 and still work ok

    A popular aftermarket choice with the correct vent tube provision uses the Optima sealed battery intended for a Mazda Miata

    12 Volt (12v) Toyota Prius Auxilary Battery for 2004, 2005, 2006, 2007, 2008 and 2009 with installation kit and free shipping

    Its possible to make any other 12 vdc battery fit, but I do not recommend that. A regular battery isn't sealed and doesn't have a vent tube provision
     
  3. PriusLewis

    PriusLewis Management Scientist

    Joined:
    Feb 25, 2009
    1,002
    84
    7
    Location:
    Denver Metro
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    The 12V side of the system is much like that of any car, and the 12V battery needs replacing at the same or shorter interval. It's very small for a car battery (looks like one for a big motorcycle) so is taxed a bit more, although it doesn't have to start the car.

    When the 12V battery is dieing, there have been a lot of different observed, strange effects. Your charge indicator is a good example. Note that the charge indicator is for the other battery, the traction battery, not the 12V. It's the traction battery that has been showing a much better than predicted lifespan (and the predictions were over 100,000 miles).

    Just like with other cars, you don't have to go to the dealer to buy a 12V battery. You can go to Sears or wherever. However, many on the board are using premium 12V batteries to get longer life and better battery performance, such as the Optima.

    As for a drain from your aftermarket stereo, it is impossible to diagnose from a post, but if you have a remote amp that remains on after the car is turned off it will be hard on the battery. Due to the small size, any drain has a bigger effect than it would on a larger car battery. Note that most modern amps have sensing technology that, when it sees no signal coming in will shut itself down. Or they're wired to a circuit from the head unit that is used specifically to tell the amp when the head unit is on.

    I'd for sure replace the 12V battery first. That should cure your issues. If the new battery goes dead, then start looking for a drain.
     
  4. Actual Mileage

    Joined:
    Aug 10, 2006
    153
    2
    0
    Location:
    Portland. Maine
    Vehicle:
    Other Hybrid
    Model:
    N/A
    OK. I am a moron. Moving on from there -

    If the battery is back by my subwoofer, then what is the thing under the hood? Just a charging point?
     
  5. PriusLewis

    PriusLewis Management Scientist

    Joined:
    Feb 25, 2009
    1,002
    84
    7
    Location:
    Denver Metro
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    Toyota provides a "tap" to the 12V circuit under the hood to allow you to jump the system (since there is no way to get into the hatch without voltage, this is a Good Thing - had it been a British car, you would have had to disassemble the hatch to get in :D ).
     
  6. Actual Mileage

    Joined:
    Aug 10, 2006
    153
    2
    0
    Location:
    Portland. Maine
    Vehicle:
    Other Hybrid
    Model:
    N/A
    Yes, but - it would have been a sweet dark green color that makes women swoon. When it ran.
     
    1 person likes this.
  7. b2j2

    b2j2 Member

    Joined:
    May 27, 2008
    46
    2
    0
    Location:
    Edgecomb, Maine
    Vehicle:
    2007 Prius
    Model:
    N/A
    Lucas, "Prince of Darkness"!
     
  8. Actual Mileage

    Joined:
    Aug 10, 2006
    153
    2
    0
    Location:
    Portland. Maine
    Vehicle:
    Other Hybrid
    Model:
    N/A
    Thank you for helping me to waste more time on the internet whilst increasing my knowledge of British humor.

    Steady on Jeeves.
     
  9. Actual Mileage

    Joined:
    Aug 10, 2006
    153
    2
    0
    Location:
    Portland. Maine
    Vehicle:
    Other Hybrid
    Model:
    N/A
    Lucas marketed its early headlights under the brand name "King of the Road".[12] Joseph Lucas, the founder of Lucas Industries was humorously known as the Prince of Darkness in North America because of the electrical problems common in Lucas-equipped cars, especially British Leyland products. Whether the fault lay with Lucas or British Leyland cost-cutting is disputed. As Joseph Lucas died in 1902 and British Leyland was only formed in 1968, some 66 years later, this title is undeserved. This perception also could be connected with early supply problems of the 'King of the Road' lighting products within the North American Markets during the late 1890s and early 1900s or this could also be attributed to the reputation that the company used small gauge wiring in vehicles which tend to wear out or corrode quickly.
     
  10. PriusLewis

    PriusLewis Management Scientist

    Joined:
    Feb 25, 2009
    1,002
    84
    7
    Location:
    Denver Metro
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    Why do the Brits drink warm beer? They all own Lucas refridgerators.

    Why didn't the Germans bomb a Lucas factory during WW II? They considered them allies.

    Why did all Brit cars have intermittent windshield wipers? They were made by Lucas.

    But it could be worse. If you've owned old Italian iron, you come to despise Marelli. In the Alfa club we used to say that people fired from Lucas for incompetence went to Marelli as managers.
     
    1 person likes this.
  11. qbee42

    qbee42 My other car is a boat

    Joined:
    Mar 2, 2006
    18,058
    3,073
    7
    Location:
    Northern Michigan
    Vehicle:
    2006 Prius
    By whom? No battery lasts forever. For that matter, neither do mechanical parts. When you buy a conventional car, does the salesman point out that eventually the transmission will fail?

    Tom
     
  12. Actual Mileage

    Joined:
    Aug 10, 2006
    153
    2
    0
    Location:
    Portland. Maine
    Vehicle:
    Other Hybrid
    Model:
    N/A
    Trans what?
     
  13. nerfer

    nerfer A young senior member

    Joined:
    Mar 1, 2006
    2,505
    232
    28
    Location:
    Chicagoland, IL, USA, Earth
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    3-5 years is what the industry says, but in reality it's typically longer. They want to scare people into buying replacement batteries early...pretty soon the pre-winter commercials to that effect will start up again. (Kind of like oil changes every 3K miles when the auto manufacturer says differently). My 12V batteries typically have lasted 7 years in previous cars. The 12V aux battery in the Prius is a little smaller and used a bit differently, so can't really say for sure on this.

    OTOH, the HV (high-voltage) battery, AKA traction battery, has a warranty for 8 years or 96,000 miles (slightly more in California I think), so for most car owner's point of view, that is "forever", since it's longer than they'll keep the car. Several Prius owners have documented going more than 250K miles on the original HV batteries (provided you never try to run the car past the purple bars on electric only when it runs out of gas - that will drastically shorten the HV battery life).

    All that said, you have a problem with your system, and it could be radio related. If it was the battery, it should be getting worse with time, after short drives, and in cold weather (you don't have your location in your profile, so I'm not sure if that's a factor for you). But if the aux battery goes, it can throw a bunch of warnings, including the triangle of doom on the front dash.
     
  14. qbee42

    qbee42 My other car is a boat

    Joined:
    Mar 2, 2006
    18,058
    3,073
    7
    Location:
    Northern Michigan
    Vehicle:
    2006 Prius
    Trans fat. It's bad for you.

    Tom
     
  15. Actual Mileage

    Joined:
    Aug 10, 2006
    153
    2
    0
    Location:
    Portland. Maine
    Vehicle:
    Other Hybrid
    Model:
    N/A

    Oh good. I thought you were talking about my 1989 20th Anniversary Turbo Trans Am with a turbocharged Buick 3.8L V6.

    Which I converted to run on bacon fat.
     
  16. martinw

    martinw New Member

    Joined:
    Jun 8, 2009
    49
    11
    0
    Location:
    North Hollywood, CA
    Vehicle:
    2010 Prius
    Model:
    III
    I think I see the problem here, at least when referring to aftermarket lights. It looks like there is a misperception that the aftermarket lights were intended to be functional. Easy mistake to make, but in England at the time I remember it was pretty common knowledge that the aftermarket Lucas lights were purely aesthetic, and should under no circumstances have their original opaque plastic covers removed. The whole purpose of the lights was to impress the masses with the fact that you had attached extra lighting to your vehicle and were therefore cooler than them. Functionality as lights was entirely beside the point and so was never really a feature. I guess when these lights were exported to North America this bit of rather important folk knowledge did not make the transition and people actually tried to use the things as lights?
     
  17. PriusLewis

    PriusLewis Management Scientist

    Joined:
    Feb 25, 2009
    1,002
    84
    7
    Location:
    Denver Metro
    Vehicle:
    Other Non-Hybrid
    Model:
    N/A
    I'd agree, except that I have to admit the Lucas Square 8 was a fantastic driving light. I still have a pair of Square 8 fog lights in a box, and have been threatening to put them behind the lower grill in my non-fog-light equipped 2006 Prius. If I could find a pair of driving light lenses I'd prefer that to the fogs. Never had a bit of trouble with either the Square 8's or the Flamethrowers.
     
  18. lamontcranston

    lamontcranston Umbra Tenet

    Joined:
    Jul 28, 2009
    212
    17
    0
    Location:
    Southern California
    Vehicle:
    2010 Prius
    Model:
    II
    I don't know if this applies, but I've had to replace the batteries in pretty much every car I've owned since I moved to Southern California at about 3.5 years. I live in the SoCal desert where it's common for temps to be over 100 during the day for six months out of the year.

    I was told at one point, and this may be hooey... that a sealed battery fails earlier in extreme temperatures because there's still some evaporation even if it's fully sealed and there's no way to add water back in.

    I'm still not sure why the Prius needs a second battery... couldn't there just be a transformer to step down the voltage from the traction battery to run the accessories? I'm sure that's been asked and answered a million times already.
     
  19. Celtic Blue

    Celtic Blue New Member

    Joined:
    Aug 4, 2008
    2,224
    139
    0
    Location:
    Midwest
    Vehicle:
    2008 Prius
    Depends on the vehicle, climate, and how it is used. My Tundra V8 goes through batteries about every 2 years...haven't paid for one in a long time as they are still under full warranty when I exchange them. F-150 V8 had a similar appetite and a really awful ignition system--I nicknamed it the crossfire and made an elaborate loom to keep the plug wires well away from one another.

    My 240 battery lasted at least 7 years...it took next to nothing to turn that engine over and it fired instantly. I was having trouble with the seat belt glides before the battery ever failed. The Honda took about 3-5 years per battery. About 5 on the first, and progressively shorter after that until I changed out the ignition switch.

    The K-car batteries did okay.

    Had an old AMC V8 as a kid that ate batteries for breakfast. Apparently Lucas must have designed their ignition system which had some sort of weird nice person random short that I never could track down. I kept two fully charged spares on the floorboard of the back seat. It's the only vehicle I've ever had that tried to start on me while I was standing in front of it. I was staring at some damage to the loose fan cowling under the hood...I wasn't touching anything and had the only extant ignition key in my pocket. Fortunately I had not yet reached into the fan to readjust/reattach the cowling. When this happened I felt for the key in my pocket (check), then lowered the hood to see if someone was in the driver's seat--this on a farm with the nearest neighbor over 1/4 mile away. To make it stop I yanked off one of the battery terminals.
     
  20. richard schumacher

    richard schumacher shortbus driver

    Joined:
    Mar 27, 2004
    7,663
    1,037
    0
    Location:
    United States
    Vehicle:
    2004 Prius
    Model:
    N/A
    Technically easy, but that would be one more way in which a failure could expose people to dangerous voltages. It's safer to have the systems more nearly separate.