1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Dead touch screen on multi function display

Discussion in 'Gen 2 Prius Audio and Electronics' started by timbck2, Nov 18, 2012.

  1. timbck2

    timbck2 Junior Member

    Joined:
    Mar 9, 2010
    8
    1
    0
    Location:
    Santa Fe, NM
    Vehicle:
    2007 Prius
    Model:
    N/A
    Has anyone had their touch screen stop responding to input of any sort? I have an '07 Prius without factory Nav and about a month ago I had to replace the MFD because of this (it still displayed fine, just wouldn't respond to touches). The dealership wanted almost $3,000 for the part (new) and installation (really?! $3 grand for a 7" touch screen?) so I said forget it.

    Then I realized that I wouldn't be able to fully control the A/C or audio anymore, pair a Bluetooth phone, etc. So I got the service tech at the dealership to give me the part number I needed, and I went online looking for it.

    I input my contact info and what I needed at a site that then sent email requests out to salvage yards all over the country, and within a couple of hours a guy in Jacksonville, FL called me (I'm in Santa Fe, NM) and offered me a used unit from a car on his salvage yard for $500 shipped. I paid, he sent it (and it arrived in perfect condition), and the dealer installed it for $60 labor. Not bad, huh?

    Anyway, what I was wondering is whether this failure is common and whether I have any claim I can make with Toyota (even though the vehicle is long out of warranty)?
     
    Wile-E-Coyote likes this.
  2. DaveFromDecatur

    DaveFromDecatur Junior Member

    Joined:
    Jul 5, 2010
    26
    3
    0
    Location:
    Decatur, Georgia
    Vehicle:
    2004 Prius
    Model:
    N/A
    I've recently developed a similar problem with my 2004 Prius. It's got factory GPS, Bluetooth hands-free, the works. (I bought it used a couple of years ago.) Not only won't the touch screen respond, but it doesn't show any information, or shows only partial information. After awhile, it may come back on; or not. A very reliable Toyota dealer in metro Atlanta told me Toyota wanted over $5,000 for the part! Like you, I said, well, I can live with the problem, esp. since the audio and climate controls on the steering wheel still worked. And like you, I soon realized that there were a lot of things I actually couldn't do, starting with the GPS. Somehow it's connected to the audio system, which also cuts in and out, and leaves the Bluetooth phone connection unreliable.

    I consider $5,000 (about 1/4 the original price of the car!) a total rip-off, esp. since the car is barely out of warranty (it only has 110K on it), so I've been thinking of doing the kind of searches you did. Once before, I got a replacement stereo for $100 on eBay, instead of the $1000 Toyota wanted.

    So I'm very encouraged to hear of your success. What site did you use to search for the part and get in touch with all the salvage yards?
     
  3. stillageek

    stillageek Junior Member

    Joined:
    Apr 17, 2005
    52
    3
    0
    Vehicle:
    2004 Prius
  4. Adam Leibovitch

    Joined:
    Oct 14, 2012
    498
    102
    0
    Location:
    Los Angeles, CA
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    My MFD died on me in the 2008 also. I found lots of threads about it but Toyota said they never seen the issue before. Typical.
     
    PriusGuy32 likes this.
  5. DaveFromDecatur

    DaveFromDecatur Junior Member

    Joined:
    Jul 5, 2010
    26
    3
    0
    Location:
    Decatur, Georgia
    Vehicle:
    2004 Prius
    Model:
    N/A
    Thanks for this tip, stillageek. I'm in touch with them, and hoping for the best.
     
  6. timbck2

    timbck2 Junior Member

    Joined:
    Mar 9, 2010
    8
    1
    0
    Location:
    Santa Fe, NM
    Vehicle:
    2007 Prius
    Model:
    N/A
    [quote="DaveFromDecatur] So I'm very encouraged to hear of your success. What site did you use to search for the part and get in touch with all the salvage yards?[/quote]

    I wish I could tell you but I can't remember the name of the site and I have since cleared my browser history and was unable to find it again. After being contacted by someone at the yard who eventually sold me the part, the remainder of the transaction was carried out over the phone.

    However, there are several such services that let you search salvage yards' inventories online; do a Google search for "used car parts" and see what you get.
     
  7. DaveFromDecatur

    DaveFromDecatur Junior Member

    Joined:
    Jul 5, 2010
    26
    3
    0
    Location:
    Decatur, Georgia
    Vehicle:
    2004 Prius
    Model:
    N/A
    I wish I could tell you but I can't remember the name of the site and I have since cleared my browser history and was unable to find it again. After being contacted by someone at the yard who eventually sold me the part, the remainder of the transaction was carried out over the phone.

    However, there are several such services that let you search salvage yards' inventories online; do a Google search for "used car parts" and see what you get.[/quote]
    Thanks. I'm hopeful the folks at the site stillageek recommended will come through, but if not that will be my next move.
     
  8. timbck2

    timbck2 Junior Member

    Joined:
    Mar 9, 2010
    8
    1
    0
    Location:
    Santa Fe, NM
    Vehicle:
    2007 Prius
    Model:
    N/A
    Are you still on the original 12V battery? I ask because while reading on the site stillageek recommended a dying battery is mentioned over and over again as the cause of at least some of the symptoms you described. I know that wasn't the problem with my multifunction display because I had replaced my battery only about 5 months ago when it died completely.
     
  9. DaveFromDecatur

    DaveFromDecatur Junior Member

    Joined:
    Jul 5, 2010
    26
    3
    0
    Location:
    Decatur, Georgia
    Vehicle:
    2004 Prius
    Model:
    N/A
    Yeah, I noticed that too, and it's got me thinking. I replaced the battery (expensive!) in May 2010. I would hope I wouldn't have to do it again so soon. However, since I'm also experiencing the very annoying red-triangle warning about the headlight-leveling system, which I've seen may also be related to 12V battery failure, I am going to investigate that battery before spending bucks on anything else.
     
  10. timbck2

    timbck2 Junior Member

    Joined:
    Mar 9, 2010
    8
    1
    0
    Location:
    Santa Fe, NM
    Vehicle:
    2007 Prius
    Model:
    N/A
    I would too, even though the battery is a fairly expensive item too. If you do end up replacing the 12V battery, I hope you don't have to go through what I did, which is replace it from the inside of the car because my rear hatch would not open (turns out even the "manual" release for the hatch still requires power and my battery was DEAD, wouldn't even jump start!)
     
  11. stillageek

    stillageek Junior Member

    Joined:
    Apr 17, 2005
    52
    3
    0
    Vehicle:
    2004 Prius
  12. timbck2

    timbck2 Junior Member

    Joined:
    Mar 9, 2010
    8
    1
    0
    Location:
    Santa Fe, NM
    Vehicle:
    2007 Prius
    Model:
    N/A
  13. DaveFromDecatur

    DaveFromDecatur Junior Member

    Joined:
    Jul 5, 2010
    26
    3
    0
    Location:
    Decatur, Georgia
    Vehicle:
    2004 Prius
    Model:
    N/A
    So, here's the outcome of my tale: I ended up just looking on eBay, and was fortunate to find that several used MFDs were available. I settled on one that both was inexpensive and had a good warranty. It was from LKQ, and cost about $325. My longtime mechanic installed it for $160. His shop had never done this before, and I printed out the instructions from Prius MFD Touchscreen Repair, which he found helpful. (I corresponded with Steve at that site about whether he had a unit he could sell me, but they don't do that any more. I'd have had to take it out, or have it taken out, and ship it to him for repair, which seemed overly complicated.)

    The used unit (out of a 2005 vehicle) is working well after a brief tryout. I'm having a little problem with Bluetooth connection with my phone, but I'm sure I'll get that straightened out.

    Thanks for folks' help here. One further outcome of this is that I've lost a lot of confidence in Toyota's manufacturing process and regard for their customers: again, they want $5,000 for a new MFD unit. Think a minute about how many high-powered standalone computers you could buy for $5,000. There's no way to justify a price like that.
     
    Data Daedalus and LauraPasadena like this.
  14. LauraPasadena

    LauraPasadena New Member

    Joined:
    Aug 1, 2013
    1
    0
    0
    Vehicle:
    2006 Prius
    Model:
    N/A

    my husband had the same problem with his 2006 Prius. Half of the MFD was frozen, so the car was stuck on one radio station and one A/C setting. The dealership wanted $1,000 for just the part. However, my husband is in the insurance business so tracked down the part from a junkyard in Fontana, CA (which is junkyard central, apparently). The part they gave him turned out to be incompatible with his car; however, on the second visit he took the part # with him and got the correct part. (It may be advisable to get a guarantee that you can return the part if it doesn't work for some reason.) The second time, the part worked fine, and total cost was $350/used MFD plus $110 dealer installation. It's too bad that this problem is showing up after warranty; maybe it will turn into a recall issue if there are enough complaints. It does affect the safe operation of the car.
     
  15. BluPr09

    BluPr09 New Member

    Joined:
    Oct 7, 2013
    2
    0
    0
    Vehicle:
    2009 Prius
    Model:
    Two
    I have the same issue. Does anyone know if we can downgrade to a non nav from nav? Parts appear much cheaper. Thanks for any help!
     
  16. Apollo Grace

    Apollo Grace Junior Member

    Joined:
    Aug 18, 2012
    3
    0
    0
    Location:
    Chapel Hill, NC
    Vehicle:
    2007 Prius
    Model:
    N/A
    I think you'll also lose some other advanced features, like the Bluetooth for phones. I'm in the same situation, right now, choosing a part to replace my 86110-47220 (2007 w/Nav). Think I might have to pay about 500, that's what I'm seeing.
     
  17. Apollo Grace

    Apollo Grace Junior Member

    Joined:
    Aug 18, 2012
    3
    0
    0
    Location:
    Chapel Hill, NC
    Vehicle:
    2007 Prius
    Model:
    N/A
    Hey, I'm seeing some EBay listings for part 86110-47071, and it says it's got the nav, and is for model years 05-09. Does anyone know if this will work in my Prius, which had a 86110-47220? (My screen has been totally dead for months.)
     
  18. TampaPrius.com

    TampaPrius.com Active Member

    Joined:
    Feb 20, 2013
    461
    296
    0
    Location:
    Tampa, Florida
    Vehicle:
    2008 Prius
    Model:
    N/A
    You have to use the same part number or the connections will be different. Some have back-up camera, JBL and/or bluetooth and some don't. Very simple repair the only tools required are 10mm socket and phillips screwdriver. Find a cheap one that has your exact part number on eBay or Car-Part.com--Used Auto Parts Market. I have replaced about 10 of these and have paid between $60-$175 the ones with nav are usually more expensive. Search youtube for a video showing dash or radio removal and just do it. Save some money.
     
  19. MikeSF

    MikeSF Member

    Joined:
    Apr 19, 2006
    416
    19
    0
    Location:
    San Francisco
    Vehicle:
    2006 Prius
    Is there a way to find out the part you need without removing it first? Replacement doesn't look TOO difficult, but if possible I'd like to only do the dash removal bit once (I always have a habit of breaking or bending those plastic clips that hold everything in).
     
  20. MikeSF

    MikeSF Member

    Joined:
    Apr 19, 2006
    416
    19
    0
    Location:
    San Francisco
    Vehicle:
    2006 Prius
    Nevermind, I just popped open the panel after watching a youtube video that lasted all of 6 minutes to completely replace it. 47230... of course it would be the one that I don't see for $100