1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Battery dropping to low purple on start up

Discussion in 'Gen 2 Prius Care, Maintenance and Troubleshooting' started by gazoo6045, Mar 21, 2017.

  1. gazoo6045

    gazoo6045 Junior Member

    Joined:
    Oct 27, 2014
    11
    1
    0
    Location:
    covina
    Vehicle:
    2006 Prius
    Model:
    Two
    when i turn on my 06 prius in the morning i i have 4 bars that are blue. as soon as i turn on the heat the bars drop to one bar of purple within thirty seconds. is this normal?
     
  2. JC91006

    JC91006 Senior Member

    Joined:
    Nov 10, 2013
    16,464
    8,377
    0
    Location:
    Los Angeles, CA
    Vehicle:
    2008 Prius
    Model:
    II
    That's not normal, you have a weak battery. Need to charge and balance before it fails
     
    Samprocat and Kramah313 like this.
  3. gazoo6045

    gazoo6045 Junior Member

    Joined:
    Oct 27, 2014
    11
    1
    0
    Location:
    covina
    Vehicle:
    2006 Prius
    Model:
    Two
    just changed to rebuild battery....last week..
     
  4. Sam Spade

    Sam Spade Senior Member

    Joined:
    Dec 3, 2016
    2,036
    1,020
    0
    Location:
    USA
    Vehicle:
    2017 Prius c
    Model:
    Four
    Hope it has a warranty.
     
  5. JC91006

    JC91006 Senior Member

    Joined:
    Nov 10, 2013
    16,464
    8,377
    0
    Location:
    Los Angeles, CA
    Vehicle:
    2008 Prius
    Model:
    II
    Doesn't sound like it was rebuilt, sounds like someone swapped a module and didn't charge and balance
     
  6. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    107,571
    48,862
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    what company did you get it from?
     
  7. uart

    uart Senior Member

    Joined:
    Sep 7, 2009
    4,215
    1,200
    0
    Location:
    Australia
    Vehicle:
    2005 Prius
    Not a good sign for a "new" battery, however pretty much standard fair for an old worn battery. I've got a 2005 model with 300,000 km that's still on the original battery, and mine will do that every time unless I let it warm up for about 45 seconds before driving.

    Other than that mine drives perfectly and still gets great fuel economy. So I just let it warm up for a minute before driving in the morning, no more purple one-two bar battery issue.

    Before the cats get up to temperature the Prius tries to use the battery more than the engine, so it takes a bit of a beating in the first 60 seconds of driving if you don't let it warm up. Traction batteries in prime condition cope with it ok, old warn ones not quite so well.
     
  8. Sam Spade

    Sam Spade Senior Member

    Joined:
    Dec 3, 2016
    2,036
    1,020
    0
    Location:
    USA
    Vehicle:
    2017 Prius c
    Model:
    Four
    While it is somewhat sad, those opting for a "rebuilt" battery should ask EXACTLY what the word "rebuilt" means to that supplier.
    There is no standard definition.
     
  9. JC91006

    JC91006 Senior Member

    Joined:
    Nov 10, 2013
    16,464
    8,377
    0
    Location:
    Los Angeles, CA
    Vehicle:
    2008 Prius
    Model:
    II
    The fix is simply to charge and balance. Nothing really too complicated
     
    jerrymildred and Samprocat like this.
  10. MTL_hihy

    MTL_hihy Active Member

    Joined:
    Sep 2, 2013
    536
    261
    0
    Location:
    Maritimes, Canada
    Vehicle:
    Other Hybrid
    Model:
    N/A
    Modules probably need to be grid charged then load tested to ensure all is well of that battery was recently rebuilt.
     
  11. JC91006

    JC91006 Senior Member

    Joined:
    Nov 10, 2013
    16,464
    8,377
    0
    Location:
    Los Angeles, CA
    Vehicle:
    2008 Prius
    Model:
    II
    Well it is what it is, charge and balance and hope for the best. If OP is going to take it apart again, he should test everything and clean the bus bars too
     
  12. 'LectroFuel

    'LectroFuel Senior Member

    Joined:
    Feb 3, 2016
    880
    673
    0
    Location:
    San Juan Capistrano, CA
    Vehicle:
    2018 Tesla Model 3
    Model:
    N/A
    By charge and rebalance do you mean something like a Prolong reconditioner? Do those work well?
     
  13. JC91006

    JC91006 Senior Member

    Joined:
    Nov 10, 2013
    16,464
    8,377
    0
    Location:
    Los Angeles, CA
    Vehicle:
    2008 Prius
    Model:
    II
    Yes and yes
     
  14. jerrymildred

    jerrymildred Senior Member

    Joined:
    Oct 28, 2016
    11,490
    14,095
    0
    Location:
    Tampa, FL
    Vehicle:
    2017 Prius
    Model:
    Two
  15. MTL_hihy

    MTL_hihy Active Member

    Joined:
    Sep 2, 2013
    536
    261
    0
    Location:
    Maritimes, Canada
    Vehicle:
    Other Hybrid
    Model:
    N/A
    jerrymildred likes this.
  16. sandman

    sandman Member

    Joined:
    Mar 3, 2008
    277
    31
    0
    Location:
    kentucky
    Vehicle:
    2008 Prius
  17. jerrymildred

    jerrymildred Senior Member

    Joined:
    Oct 28, 2016
    11,490
    14,095
    0
    Location:
    Tampa, FL
    Vehicle:
    2017 Prius
    Model:
    Two
    I would think it would help. Not sure how much it would get you long term with that many miles. Maybe @jeff652 will be able to give you a better idea. I think it would depend on how bad any particular cell is. If it's just badly out of balance, I'd expect it to help quite a bit if you do the full reconditioning routine.

    Edit to answer the other question: It's not very hard at all if you're reasonably handy. You have to take out some panels to access the battery and its fan. There's a little controller box that you have to wire into the cable to that fan. And, of course, you have a couple wires to connect to the battery pack. It'll probably take a couple hours if you haven't done it before.
     
  18. dolj

    dolj Senior Member

    Joined:
    May 14, 2012
    7,448
    3,751
    0
    Location:
    Wellington, New Zealand
    Vehicle:
    2007 Prius
    Model:
    N/A
    Specifically for this situation, try letting the car sit in READY (with HVAC off) and wait until the ICE shuts off which takes about 50 seconds. It seems like a lot longer, but if you time it you will see that is ~50 secs. This signals moving from stage 1 to Stage 2 of the Prius engine warm up cycle. (Read one about the 5 stages of Prius warm up in my sig.)

    Why this may help, is that during stage 1, the Prius almost exclusively tries to use the electric motor to propel the car, so that the ICE can be configured in a very inefficient (fuel economy-wise) but hot running configuration to get the initial engine temperature up quicker. Because it uses the electric motor to propel the car, it draws heavily on the HV battery, and if your HV battery is at the poor end of the scale, it is quite taxing on it. If your HV battery is at the good end of the scale, it has no problem propelling the car, as it is designed to do. YMMV.

    hope this helps.
     
  19. sandman

    sandman Member

    Joined:
    Mar 3, 2008
    277
    31
    0
    Location:
    kentucky
    Vehicle:
    2008 Prius
    Okay, battery getting much worse. It's staying in purple(SOC is 20-35)most of my commute on interstate ( 70 miles). when I get off interstate it comes back up in the blue. Motor really struggles on hills, I am afraid its going to blow. Worse in the morning when its dark. Here are my options

    1. I called dealership they quoted me a price of $3700 out the door for new hybird battery.
    2. I called around, and a few junk yards have them for $850(2009 114,000)
    3. Trade it in for a new 2017 Prius Three (Blizzard Pearl).
     
  20. uart

    uart Senior Member

    Joined:
    Sep 7, 2009
    4,215
    1,200
    0
    Location:
    Australia
    Vehicle:
    2005 Prius
    It appears that you're driving your Prius too hard for it's current age and condition. If the SOC is staying in purple for most of your 70 mile interstate commute then it means that the engine is just not getting enough opportunity to charge the HV battery. All of the power that the engine can muster is being commanded (by you) to go to the wheels, so none goes to the battery.

    Even with a brand new HV battery, it can only cover for lack of engine power for a limited amount of time and then you're still going to end up with low SOC if the engine can't provide enough power.

    A new HV battery will definitely help, but it might not completely solve your issues if the engine is genuinely sick (low on power).

    As a temporary measure can you try warming engine for 45 sec to1 minute before driving as I suggested above. And try driving just a few MPH slower and pushing it less up hills.