1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Dr Prius Life Expectancy Test cuts off early- implications?

Discussion in 'Gen 2 Prius Main Forum' started by ericspoor, May 23, 2020.

  1. ericspoor

    ericspoor Member

    Joined:
    Jul 25, 2018
    76
    37
    0
    Location:
    austin
    Vehicle:
    2005 Prius
    Model:
    Base
    Hey all,

    wondering who might have some experience with the dr prius app; i try to run the life expectancy test but my battery gets low enough that the car starts charging with the engine before it can finish. As a result the test ends early and my estimated battery capacity is 57%. I have a hunch that the 57% is an overestimation since the app doesnt realize the reason the test ended was that my battery was too low to continue, rather than an accidental charge. Any thoughts or input on that thesis? Attached a pic of the end of the test as well as a general screenshot- should i be concerned about the internal resistance shown?

    Many thanks for any ideas!
     

    Attached Files:

    jacktheripper likes this.
  2. SFO

    SFO Senior Member

    Joined:
    Feb 7, 2017
    5,286
    4,225
    0
    Location:
    Northern California
    Vehicle:
    2007 Prius
    Model:
    N/A
    @ericbecky has some experience with that App, and you should also try sending a PM to the App developer @jacktheripper

    Please report back with what you learn.
     
    Raytheeagle likes this.
  3. jacktheripper

    jacktheripper Active Member

    Joined:
    Dec 13, 2017
    229
    465
    4
    Location:
    USA
    Vehicle:
    2010 Prius
    Model:
    Base
    Hi Eric,

    Dr. Prius App was designed that way.
    The battery blade reach it's lowest point (around 7.0 volt) right before starting to charge, that's when the App knows the discharge cycle is over and put all the number together for you. Don't need to worry about IR until they hit 30+ milli-ohm.

    btw, 57% for a 2005 Gen2 is pretty awesome, original pack or 2nd?

    Jack
     
    #3 jacktheripper, May 24, 2020
    Last edited: May 24, 2020
    ericspoor likes this.
  4. ericspoor

    ericspoor Member

    Joined:
    Jul 25, 2018
    76
    37
    0
    Location:
    austin
    Vehicle:
    2005 Prius
    Model:
    Base
    Thanks Jack! Very much appreciate your expertise. You are correct, previous owner replaced battery with OEM replacement in 2011 or so.
     
    jacktheripper likes this.