1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Can Gen 3 prius fuel gauge be reset?

Discussion in 'Gen 3 Prius Technical Discussion' started by Oldfatdude, May 5, 2021.

  1. Oldfatdude

    Oldfatdude Junior Member

    Joined:
    May 5, 2021
    12
    3
    0
    Location:
    USA
    Vehicle:
    2010 Prius
    Model:
    Four
    I drive over 300 miles a day. I use between 8 and 10 gallons of gas.
    My fuel gauge now shows almost full all the time, even after driving 350 miles
    Is there a way to reset the float like the method used to reset the Gen 2 models?
    Thanks
    Mike
     
  2. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    107,571
    48,862
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    i think there might be. try googling some different terms
     
  3. Oldfatdude

    Oldfatdude Junior Member

    Joined:
    May 5, 2021
    12
    3
    0
    Location:
    USA
    Vehicle:
    2010 Prius
    Model:
    Four
    I've been searching through the internet and YouTube for days... that's why I asked in this forum.
     
  4. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    107,571
    48,862
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    two suggestions i find: disconnect 12v neg for a minute. if that doesn't work:

    replace the sending unit. it is located through an access hole under the rear seat.

    the proceedure is in the service manual, or avi's advanced auto said he disconnects the fuel pump, and runs the engine to release the fuel pressure.
     
    Oldfatdude likes this.
  5. Maarten28

    Maarten28 Active Member

    Joined:
    Jul 13, 2014
    414
    222
    1
    Location:
    Netherlands
    Vehicle:
    2011 Prius
    Model:
    Three
    Have you visually inspected the float? Is it not sticking in the full position?
     
    Mendel Leisk likes this.
  6. Oldfatdude

    Oldfatdude Junior Member

    Joined:
    May 5, 2021
    12
    3
    0
    Location:
    USA
    Vehicle:
    2010 Prius
    Model:
    Four
    I haven't tried anything yet. Since Gen 2 has an electronic procedure, I was hoping that Gen 3 would have something similar.
     
  7. Oldfatdude

    Oldfatdude Junior Member

    Joined:
    May 5, 2021
    12
    3
    0
    Location:
    USA
    Vehicle:
    2010 Prius
    Model:
    Four
    I was trying to avoid physical labor, lol
    (I'm 70)
     
    bisco likes this.
  8. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    107,571
    48,862
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    i hear you!
     
  9. Oldfatdude

    Oldfatdude Junior Member

    Joined:
    May 5, 2021
    12
    3
    0
    Location:
    USA
    Vehicle:
    2010 Prius
    Model:
    Four
    I've been looking online for a definitive picture of where the float is located. I don't have a repair manual but I'm guessing the float is located on or near the fuel pump. Does anyone have a picture of the location, or a description?
    Does the pump need to be removed or can the float be removed separately?
    I can't find anything on YouTube or anywhere.
    Thanks
     
  10. Oldfatdude

    Oldfatdude Junior Member

    Joined:
    May 5, 2021
    12
    3
    0
    Location:
    USA
    Vehicle:
    2010 Prius
    Model:
    Four
    I'll try your suggestions this weekend, thanks
     
  11. Oldfatdude

    Oldfatdude Junior Member

    Joined:
    May 5, 2021
    12
    3
    0
    Location:
    USA
    Vehicle:
    2010 Prius
    Model:
    Four
    I just unplugged the fuel pump. Engine died from fuel starvation. Got the fatal 'check hybrid system'.
    Float still stuck at top.
    Didn't work.
    (I can erase codes, errors gone, but fuel gauge still effed up.)
     
  12. Oldfatdude

    Oldfatdude Junior Member

    Joined:
    May 5, 2021
    12
    3
    0
    Location:
    USA
    Vehicle:
    2010 Prius
    Model:
    Four
    P. S. I still don't know where the float is... wish I could find a damn picture!!
     
  13. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    107,571
    48,862
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    have you tried searching for the service manual?
     
  14. Oldfatdude

    Oldfatdude Junior Member

    Joined:
    May 5, 2021
    12
    3
    0
    Location:
    USA
    Vehicle:
    2010 Prius
    Model:
    Four
    Yes, but I'd have to pay for it. Lol
    I don't want to pay for it when all I want to know is where it is, without tearing my car apart.
    I took the back seat out and took the plate off the fuel pump but I didn't see anything that looked like a float connector.
     
  15. Maarten28

    Maarten28 Active Member

    Joined:
    Jul 13, 2014
    414
    222
    1
    Location:
    Netherlands
    Vehicle:
    2011 Prius
    Model:
    Three
    The float is connected to the fuel pump which is located under the back seat (but you probably found that because you disconnected it). You need to get the big screw top off to access it.
    Here's a video:
     
    bisco and Oldfatdude like this.
  16. ASRDogman

    ASRDogman Senior Member

    Joined:
    May 29, 2018
    5,837
    3,137
    0
    Location:
    Florida
    Vehicle:
    2010 Prius
    Model:
    Two
    Thanks for the video...
    Maybe it's the coating inside the tank, but the fuel looked rusted?
    He spent the first 2 minutes showing pump....

    Where did he get the pump? Part number?

     
  17. Oldfatdude

    Oldfatdude Junior Member

    Joined:
    May 5, 2021
    12
    3
    0
    Location:
    USA
    Vehicle:
    2010 Prius
    Model:
    Four
    THANK YOU!!!
     
  18. Oldfatdude

    Oldfatdude Junior Member

    Joined:
    May 5, 2021
    12
    3
    0
    Location:
    USA
    Vehicle:
    2010 Prius
    Model:
    Four
    Absolutely perfect!!
    Thank you!
    I owe you!
     
  19. AltraStache

    AltraStache Junior Member

    Joined:
    Oct 3, 2017
    33
    10
    0
    Location:
    Wisconsin
    Vehicle:
    2007 Prius
    Model:
    Three Touring
    Any luck with correcting the issue with the fuel gauge via the float or fuel pump replacement. I thinking I might have the same issue the 2010 I just purchased. It was at a 1/2 tank when I bought it but then filled it up and now it says full even after a few days of driving.
     
  20. Mendel Leisk

    Mendel Leisk Senior Member

    Joined:
    Oct 17, 2010
    54,480
    38,108
    80
    Location:
    Greater Vancouver, British Columbia, Canada
    Vehicle:
    2010 Prius
    Model:
    Touring
    And how many miles?

    my 2 cents: drive it a few more days, gauge will start dropping, you’ll fugedaboutit.
     
    AltraStache likes this.