1. Attachments are working again! Check out this thread for more details and to report any other bugs.

I have tried many settings but on humid mornings the outside of the windshield gets so foggy...

Discussion in 'Gen 2 Prius Main Forum' started by ukiltmybrutha, Aug 19, 2021.

  1. ukiltmybrutha

    ukiltmybrutha Member

    Joined:
    Nov 4, 2019
    139
    22
    0
    Location:
    VA
    Vehicle:
    2005 Prius
    Model:
    Touring
    ....and I get stuck using the wipers for 20 minutes to stop it from fogging over.

    There seems to be no silver bullet for this and it is very dangerous when the sun's glare hits.

    Any ideas on what the perfect settings are? I have tried AC on/recirc off and defroster on to no avail.

    Thanks.
     
  2. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    107,571
    48,862
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    i have to use the wipers too, have you tried rain x?
     
    ukiltmybrutha likes this.
  3. ukiltmybrutha

    ukiltmybrutha Member

    Joined:
    Nov 4, 2019
    139
    22
    0
    Location:
    VA
    Vehicle:
    2005 Prius
    Model:
    Touring
    I just applied Rain-x. Will see how that goes!
     
    bisco likes this.
  4. ChapmanF

    ChapmanF Senior Member

    Joined:
    Mar 30, 2008
    23,073
    14,979
    0
    Location:
    Indiana, USA
    Vehicle:
    2010 Prius
    Model:
    IV
    What's the typical temperature and dewpoint on these mornings?

    What temperature setting are you using with the defroster? It has to be high enough to warm the glass above the dewpoint. That might be a tall order before the engine is fully warmed up.

    There are electric heat elements built into the heater for use before the engine is warmed, but only around 700 watts worth. That's peanuts compared to the roughly 5300 watts of heat it can extract from the coolant when the engine is at operating temp.

    Worse, the electric elements are in two places, half in the heater core (so they can heat to any outlet), and half in the footwell duct (where they can't contribute in defrost mode). So until the engine gets warm, you're pretty much limited to 350 watts of heat you can aim at the glass.

    Meanwhile, the defrost mode tends to bring in the A/C as well. That's normally a good idea, to dry the air hitting the inside of the glass so it won't fog on the inside. But of course in drying the air it also cools it, working somewhat against your small amount of available heat trying to warm the glass to keep the outside surface clear.
     
    Meg&Bear, ukiltmybrutha and SFO like this.
  5. sam spade 2

    sam spade 2 Senior Member

    Joined:
    Mar 31, 2018
    7,035
    2,780
    0
    Location:
    USA
    Vehicle:
    2017 Prius c
    Model:
    Four
    You are over-cooling the interior.
    It should NOT be on recirc and the temp should be set so that it just barely cools.
     
    Meg&Bear likes this.
  6. Another

    Another Senior Member

    Joined:
    Jun 22, 2021
    1,802
    508
    0
    Location:
    Naples, Florida
    Vehicle:
    2007 Prius
    Model:
    Touring
  7. bat4255

    bat4255 2017 Prius v #2 and 2008 Gen II #2

    Joined:
    Nov 8, 2007
    654
    261
    0
    Location:
    Dodge Co. Wisconsin
    Vehicle:
    2017 Prius v wagon
    Model:
    Two
    With higher dew points (70-75 like we have here) this is normal.
    The temp coming out of the A/C and defrost is well below that.
    Think of the sweat on a cold beverage outside in this muggy mess, same thing.
    They only way around it I know of is no A/c or defrost.
     
  8. ChapmanF

    ChapmanF Senior Member

    Joined:
    Mar 30, 2008
    23,073
    14,979
    0
    Location:
    Indiana, USA
    Vehicle:
    2010 Prius
    Model:
    IV
    I'd still be interested in what both the morning temperatures and dewpoints are where the OP is.

    The defroster activates the A/C, which cools the incoming air a bit, but it can also be reheated if the temperature setting calls for that. Trouble is, the reheating ability is limited to about 350 watts while the engine warms up.
     
  9. bat4255

    bat4255 2017 Prius v #2 and 2008 Gen II #2

    Joined:
    Nov 8, 2007
    654
    261
    0
    Location:
    Dodge Co. Wisconsin
    Vehicle:
    2017 Prius v wagon
    Model:
    Two
    It looks to be about low 70's if VA is where he lives.
    Hourly Graphical Forecast for 37.71N 77.54W
     
  10. ChapmanF

    ChapmanF Senior Member

    Joined:
    Mar 30, 2008
    23,073
    14,979
    0
    Location:
    Indiana, USA
    Vehicle:
    2010 Prius
    Model:
    IV
    Looks like I should have similar conditions here around 7 am, might play around and see what kind of discharge temperature I can get.

    On the optimistic side, it just has to be somewhat above 70 ℉, and it's coming in already at that temperature, and so humid that the A/C might be taking out more latent than sensible heat and so not dropping its temperature very much. It remains to be seen what the electric heat elements can boost it up to, while the engine's still cold.

    I won't be able to get directly comparable results to Gen 2 because I have a Gen 3, where the electric heating is arranged differently; it's all in one unit right above the heater core, so it can be used at full power no matter what outlet is selected. Gen 2 can only use half its electric heat power for defrost, because the other unit is located in the duct to the footwell outlets.
     
  11. ChapmanF

    ChapmanF Senior Member

    Joined:
    Mar 30, 2008
    23,073
    14,979
    0
    Location:
    Indiana, USA
    Vehicle:
    2010 Prius
    Model:
    IV
    On my Gen 3, set for defrost, A/C button off (defrost uses the A/C anyway), and temp setting the discharge temp at the defrost vent was immediately about 77 ℉ and went steadily up from there as the engine warmed ... by the time the engine coolant was 120 ℉ (which only took a minute or two) the discharge temperature was over 100 ℉. The A/C compressor was winding pretty high at that point (1650 watts), but still the heating predominated; at no point was the discharge temperature lower than ambient, and it was above the dewpoint the whole time.
     
  12. fotomoto

    fotomoto Senior Member

    Joined:
    Apr 22, 2009
    5,596
    3,770
    0
    Location:
    So. Texas
    Vehicle:
    Other Hybrid
    First: CLEAN, clean, clean, the glass. A dirty film on the inside surface makes the condition worse.

    Set HVAC to Auto and use HIGHER temperature settings to get the inside and outside of the windshield close(r) to the same temps. Directing cold and humid air onto the interior side of the glass makes things worse. Use wipers.

    Yet another beneficial reason for covered/garaged parking.
     
  13. sam spade 2

    sam spade 2 Senior Member

    Joined:
    Mar 31, 2018
    7,035
    2,780
    0
    Location:
    USA
    Vehicle:
    2017 Prius c
    Model:
    Four
    No it doesn't.
    He was complaining about condensation on the OUTSIDE of the glass.
     
  14. fotomoto

    fotomoto Senior Member

    Joined:
    Apr 22, 2009
    5,596
    3,770
    0
    Location:
    So. Texas
    Vehicle:
    Other Hybrid
    Yes, I know this.

    Just as high speeds and bald tires both contribute to dangerous handling in the rain, the condition of the inside and the outside of the windshield both contribute to the overall visibility for the driver. And YES the inside can and will create condensation (just breathe on it and you'll see it on a cool, moist day). Yes, it is a minor issue compared to exterior condensation in the OP's case but it's still a contributing factor and worth mentioning since it's so easy to rectify.
     
  15. ukiltmybrutha

    ukiltmybrutha Member

    Joined:
    Nov 4, 2019
    139
    22
    0
    Location:
    VA
    Vehicle:
    2005 Prius
    Model:
    Touring
    Thanks for educating me everyone. Issue resolved with your help.

    Will post more later.