1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Parking Brake stuck engaged.

Discussion in 'Prius v Care, Maintenance and Troubleshooting' started by Eric Oines, Dec 8, 2022.

Tags:
  1. Eric Oines

    Eric Oines Junior Member

    Joined:
    Nov 18, 2017
    10
    4
    0
    Location:
    Minnesota
    Vehicle:
    2007 Prius
    Model:
    ----USA----
    2012 v 5 - Just bought it 3 days ago. We also own a 2007 Base Prius and a 98 Camry.

    I found that the snow tires from the Camry are a perfect fit for my new car. Exciting news.

    Engaged the brake, jacked it up, switched the tires. Lowered it, topped off the tires with air. Ready for a test drive.

    The car didn't want to move. I dragged it out into the alley. Big mistake. The parking brake is stuck engaged. Took half an hour and the help of neighbors to get it back into the garage.

    So, I am a confident DIY mechanic. What do I do?
     
    #1 Eric Oines, Dec 8, 2022
  2. Mendel Leisk

    Mendel Leisk Senior Member

    Joined:
    Oct 17, 2010
    55,440
    38,656
    80
    Location:
    Greater Vancouver, British Columbia, Canada
    Vehicle:
    2010 Prius
    Model:
    Touring
    Previous owner likely never used it, cable seized?

    Try capillarying some WD40 upstream from the brake end?
     
    #2 Mendel Leisk, Dec 8, 2022
  3. rjparker

    rjparker Tu Humilde Sirviente

    Joined:
    Jun 6, 2008
    7,918
    4,685
    7
    Location:
    Texas Hill Country
    Vehicle:
    2012 Prius v wagon
    Model:
    Three
    The v has drum parking brakes built into the rear disk rotors. Assuming the cabin parking brake pedal is released and up, I would jack up the rear end and attempt to pull or disconnect the cable on each wheel. If that is not possible and the cable has some slack, you will have to pull the rotors to access the drum parking brakes.
     
    #3 rjparker, Dec 8, 2022
  4. Eric Oines

    Eric Oines Junior Member

    Joined:
    Nov 18, 2017
    10
    4
    0
    Location:
    Minnesota
    Vehicle:
    2007 Prius
    Model:
    ----USA----
    So... good news and I feel stupid. It was the rims of the snow tires tightened up against the caliper that was causing the issue. When they were torqued, they were tight enough to prevent the wheel from turning. They are 15" steel rims, with 205/65/R15 tires. Even though the tire size is acceptable, the rims are too small in the center. Switched back to the all weather radials on the back. No more issue. The brakes are actually nice and clean. I removed one caliper to check the pads. Lots of wear left.

    It's not an issue on the front for some reason. I am guessing the caliper is a little smaller.

    So, I have front snows, but not rear. I may try some spacers on the back to see if I can get it to work on the 15" rims.

    Thanks for the replies!
     
    #4 Eric Oines, Dec 9, 2022
  5. Eric Oines

    Eric Oines Junior Member

    Joined:
    Nov 18, 2017
    10
    4
    0
    Location:
    Minnesota
    Vehicle:
    2007 Prius
    Model:
    ----USA----
    Do either of you know the maximum tire spacer allowed?
     
    #5 Eric Oines, Dec 9, 2022
  6. Air_Boss

    Air_Boss Senior Member

    Joined:
    Jun 2, 2012
    3,941
    1,079
    0
    Location:
    New Yawk
    Vehicle:
    2012 Prius v wagon
    Model:
    Five
    Before you go that way, be sure that lateral spacing would clear any interference.
     
    #6 Air_Boss, Dec 10, 2022
  7. jzchen

    jzchen Newbie!

    Joined:
    Apr 9, 2012
    3,298
    1,009
    0
    Location:
    Arcadia, CA
    Vehicle:
    2012 Prius v wagon
    Model:
    Five
    How does it drive with just front snow tires? I suspect you may be satisfied, because that is the position for snow traction devices if I'm not mistaken...
     
    #7 jzchen, Dec 10, 2022
  8. Eric Oines

    Eric Oines Junior Member

    Joined:
    Nov 18, 2017
    10
    4
    0
    Location:
    Minnesota
    Vehicle:
    2007 Prius
    Model:
    ----USA----
    Not a problem. Plenty of room.
     
    #8 Eric Oines, Dec 10, 2022
    Air_Boss likes this.
  9. Eric Oines

    Eric Oines Junior Member

    Joined:
    Nov 18, 2017
    10
    4
    0
    Location:
    Minnesota
    Vehicle:
    2007 Prius
    Model:
    ----USA----
    It's fine, though I haven't had to drive in anything deep yet. The tires on the back are all weather and plenty of tread.
     
    #9 Eric Oines, Dec 10, 2022
  10. jzchen

    jzchen Newbie!

    Joined:
    Apr 9, 2012
    3,298
    1,009
    0
    Location:
    Arcadia, CA
    Vehicle:
    2012 Prius v wagon
    Model:
    Five
    I just reread the manual on this, it says all four for snow tires but front only for snow chains. Don’t want to lead you astray my apologies.

    Regarding the spacers I’d get the smallest you can find 5 mm? IMG_0222.png
     
    #10 jzchen, Dec 10, 2022
  11. Mendel Leisk

    Mendel Leisk Senior Member

    Joined:
    Oct 17, 2010
    55,440
    38,656
    80
    Location:
    Greater Vancouver, British Columbia, Canada
    Vehicle:
    2010 Prius
    Model:
    Touring
    These are non Toyota rims?
     
    #11 Mendel Leisk, Dec 10, 2022
  12. jzchen

    jzchen Newbie!

    Joined:
    Apr 9, 2012
    3,298
    1,009
    0
    Location:
    Arcadia, CA
    Vehicle:
    2012 Prius v wagon
    Model:
    Five
    They’re from a Camry I believe but Toyota or not is not certain…
     
    #12 jzchen, Dec 10, 2022
    Mendel Leisk likes this.
  13. Eric Oines

    Eric Oines Junior Member

    Joined:
    Nov 18, 2017
    10
    4
    0
    Location:
    Minnesota
    Vehicle:
    2007 Prius
    Model:
    ----USA----
    Generic steel rims.
     
    #13 Eric Oines, Dec 10, 2022
    Mendel Leisk likes this.
  14. Mendel Leisk

    Mendel Leisk Senior Member

    Joined:
    Oct 17, 2010
    55,440
    38,656
    80
    Location:
    Greater Vancouver, British Columbia, Canada
    Vehicle:
    2010 Prius
    Model:
    Touring
    Camry steelies may fit?
     
    #14 Mendel Leisk, Dec 10, 2022
  15. Eric Oines

    Eric Oines Junior Member

    Joined:
    Nov 18, 2017
    10
    4
    0
    Location:
    Minnesota
    Vehicle:
    2007 Prius
    Model:
    ----USA----
    Camry steelies are 16". Snow tires are 15". I'll either get spacers or just go with front snows.
     
    #15 Eric Oines, Dec 10, 2022
    Mendel Leisk likes this.
  16. Mendel Leisk

    Mendel Leisk Senior Member

    Joined:
    Oct 17, 2010
    55,440
    38,656
    80
    Location:
    Greater Vancouver, British Columbia, Canada
    Vehicle:
    2010 Prius
    Model:
    Touring
    Yeah I'm using older-style 15" Corolla rims not problems, but that's on 3rd gen Prius hatchback. Are there stock Prius v rims in 15"??

    Addendum: no, stock is 16".

    upload_2022-12-10_18-57-8.png
     
    #16 Mendel Leisk, Dec 10, 2022
  17. Eric Oines

    Eric Oines Junior Member

    Joined:
    Nov 18, 2017
    10
    4
    0
    Location:
    Minnesota
    Vehicle:
    2007 Prius
    Model:
    ----USA----
    Mine came with 17". I do have 15" snows on a Gen 2. They're fine. The tire size is ok: 205/65 R15. It's just the generic rims don't work on the back. The front is fine. I think the calipers are lower profile. I'm sure spacers will work fine.

    We sold the Camry today for $1.
     
    #17 Eric Oines, Dec 10, 2022
    Mendel Leisk likes this.
(You must log in or sign up to post here.)