1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Double flash gas gauge on combo meter?

Discussion in 'Gen 2 Prius Main Forum' started by Tj S, Sep 18, 2016.

  1. Tj S

    Tj S Member

    Joined:
    May 3, 2016
    34
    32
    0
    Location:
    Oceanside, ca
    Vehicle:
    2005 Prius
    Model:
    ----USA----
    Can anyone tell me what my prius is trying to tell me when the gas flashes twice liked this:

    My troubles started when I replaced my combo meter on my 280k mI car due to it blacking out on a drive.
    I bought a refurbed combo meter from a repair shop in LA. The guel gauge flashes after starting starting the car and driving a few hundred feet. I took it apart several times and checked my connections with no resolution. I had the shop send me a second combo meter and same double flash. .. I reinstalled my original combo meter and is flashing now too. I carefully checked the flex cables behind the combo and didn't see anything.
    I replaced my marginal 12v battery, reset maintenance interval, recalibrated fuel gauge and will replace flex cables when I get back home.
    Does anyone have more ideas? It feels like assembly error or poor connection since the original is doing it now. Dealership wants 700 usd to install a new meter, but I may have to do this ad I don't trust the fuel level.
     
    #1 Tj S, Sep 18, 2016
    Last edited: Sep 18, 2016
  2. zorch

    zorch Junior Member

    Joined:
    Jun 3, 2007
    1
    0
    0
    Did you ever figure this out? I did the same thing...
     
  3. bisco

    bisco cookie crumbler

    Joined:
    May 11, 2005
    107,809
    48,999
    0
    Location:
    boston
    Vehicle:
    2012 Prius Plug-in
    Model:
    Plug-in Base
    defective?
     
  4. Texas Hybrid Batteries

    Texas Hybrid Batteries Senior Member

    Joined:
    Sep 7, 2014
    270
    550
    3
    Location:
    Dallas -Fort Worth
    Vehicle:
    2006 Prius
    Model:
    N/A
    We've had the blinking fuel gauge on a couple of DIY installs in the past and it's always been caused by a disconnected inclination sensor. The six pin plug (circled in red) feeds into two sensors that are under the white plastic cover (boxed in yellow). If during the disassembly/assembly that wire gets pulled on it can come unhooked from one of the sensors under the cover. Because that cover doesn't get removed during the meter install the disconnection will normally go un-noticed.

    Take the dash out and check that the inclination sensor connection to the meter is firmly seated and then remove the cover from the sensors and make sure that they are both plugged in. Once it's back together park the car on a level surface and do a zero calibration on the sensors and that should get it fixed. I've uploaded the calibration directions in case you don't have them.

    upload_2017-11-27_10-16-32.png

    Matt
     

    Attached Files:

  5. Tj S

    Tj S Member

    Joined:
    May 3, 2016
    34
    32
    0
    Location:
    Oceanside, ca
    Vehicle:
    2005 Prius
    Model:
    ----USA----
    Matt: Thank you so much for the tip. I was able to resolve the double flash fuel guage. It was a loose connection under the cover just like you described. I lived with that for 3 years and now the guage is working! THANK YOU!!!

    SM-G960U ?
     
    ColoradoCrow and TheLastMojojomo like this.
  6. ChapmanF

    ChapmanF Senior Member

    Joined:
    Mar 30, 2008
    23,331
    15,111
    0
    Location:
    Indiana, USA
    Vehicle:
    2010 Prius
    Model:
    IV
    For anyone else facing such a three-year ordeal, there is a repair manual (more info) that includes a section on the different gas gauge blink patterns and what they would be telling you.
     
  7. Name:

    Name: New Member

    Joined:
    Dec 30, 2022
    19
    4
    0
    Location:
    Salinas, CA
    Vehicle:
    2009 Prius
    Model:
    Base
    I don't know how you figured this out, but I am going to try it! Thank you very much. I've searched far and wide, and this is the first answer that addresses the situation directly.


     
    #7 Name:, Jan 8, 2023
    Last edited: Jan 8, 2023
  8. dolj

    dolj Senior Member

    Joined:
    May 14, 2012
    7,510
    3,774
    0
    Location:
    Wellington, New Zealand
    Vehicle:
    2007 Prius
    Model:
    N/A
  9. Name:

    Name: New Member

    Joined:
    Dec 30, 2022
    19
    4
    0
    Location:
    Salinas, CA
    Vehicle:
    2009 Prius
    Model:
    Base
    Sure enough, the issue is solved. Those two connectors under the cover don't have tabs and pull out easy. I took a picture, enjoy.

    PS: Do not forget to reinstall the two 12mm airbag bolts.
     

    Attached Files:

    #9 Name:, Jan 9, 2023
    Last edited: Jan 9, 2023
    Kasra likes this.
  10. sabotta

    sabotta Junior Member

    Joined:
    Nov 15, 2011
    5
    0
    0
    Location:
    Olympia
    Vehicle:
    2008 Prius
    Model:
    N/A
    I've checked the Repair Manual for the 2008 Prius on the Chilton Library site, but the repair manual never refers to "the different gas gauge blink patterns". Are you referring to a different year for the Prius?
     
  11. ChapmanF

    ChapmanF Senior Member

    Joined:
    Mar 30, 2008
    23,331
    15,111
    0
    Location:
    Indiana, USA
    Vehicle:
    2010 Prius
    Model:
    IV
    Well ... apparently I was. I was familiar with the Gen 1 repair manual, where on page DI-661-1 (in the 2001 edition), the whole page is about fuel gauge blinks.

    In that generation, there were two choices for blink pattern (a steady, 1.2 second period even blink, and a double blink that repeats every 2.4 seconds), and two choices for which segments do it (all the segments, or the display segments plus E), leading to four possible combinations.

    If it's the steady even blink and all segments are doing it, there's a communication problem between the meter and the ECM or the body ECU. If it's the double-blink and all segments are doing it, it's a fuel sender issue.

    If it's the even blink and display segments plus E are doing it, it's a fuel temperature sensor issue, and if it's the double-blink and display segments plus E are doing it, it's an inclination sensor issue.

    So it seems like the Gen 2 speaks pretty much the same language (in the video in post 1, it's the double-blink pattern, and looks like all the fuel segments plus E and F and even the MI indicator for miles on the odometer), and it did seem to be an inclination sensor issue.

    So it kind of surprises me that a Gen 2 repair manual would be missing that information that was in the Gen 1 book. But I looked in an old 2006 edition and you got me, I didn't find it there either.

    In the 2001 Gen 1 book, the strange page number DI-661-1 looks like a page that was inserted at the last minute (between 661 and 662). Maybe they also lost track of it when preparing the Gen 2 editions. :( (Or maybe it got moved somewhere else in later editions. @Elektroingenieur might know. On the techinfo site, I once used the comment feature to report a missing bit in a manual and they did respond to me, so they do watch for that kind of comment.)

    Oh, that page also describes one more blink pattern that isn't a problem. If it is just the bottom fuel segment blinking and it's the steady even blink, the car has just been powered on after battery power was out for a while, and that segment will blink until the gauge has figured out what the fuel level is.
     
    #11 ChapmanF, Mar 30, 2023
    Last edited: Mar 30, 2023
  12. Kasra

    Kasra Member

    Joined:
    Mar 10, 2018
    48
    26
    0
    Location:
    Irvine, CA
    Vehicle:
    2015 Prius
    Model:
    Four
    Mine was not unplugged; it just wanted me to redo the job, and magically worked. Thanks for pictures
     
  13. lexidium

    lexidium Active Member

    Joined:
    Nov 19, 2015
    232
    109
    0
    Location:
    manchester
    Vehicle:
    2008 Prius
    Model:
    N/A
    Isn't this a wonderful forum . . .
    You could go a lifetime and never find that out.
    Keep up the great work guys.
     
    Kasra likes this.
  14. mke039

    mke039 Junior Member

    Joined:
    Mar 21, 2008
    11
    0
    0
    Location:
    Massachusetts
    Vehicle:
    2006 Prius
    Just polished the heads up lens on a used gen II I bought which required removing combination board and had this problem after reinstalling. Sure enough that hidden connector had come off. Thanks to this thread it was an easy fix