1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Toyota (2ZR-FXE) P0171

Discussion in 'Gen 3 Prius Main Forum' started by Jarmo, Feb 13, 2023.

Tags:
  1. Jarmo

    Jarmo Junior Member

    Joined:
    Jul 22, 2019
    9
    4
    0
    Location:
    Finland
    Vehicle:
    Other Hybrid
    Model:
    Touring
    Hello from Finland,
    I have Toyota Auris Hybrid (Engine 2ZR-FXE), and mileage is around 360000km.
    EGR system and manifold cleaned up 2 years ago.
    Now I have received the fault code P0171 few times.
    I have cleaned MAF sensor Twice and it have not been dirty at all.
    I have used TOAD-Scan software to determine problem.
    Mass air flow rate are
    0.17g/s at 0 RPM
    7.4 g/s at 1300RPM

    I think that problem is long term fuel trim - Bank 1 (LTFT)... It's all the time between +25% - +35%?
    When I accelerate both LTFT and STFT rises up so i think that it is not suction leak?
    Any ideas?

    -Jarmo
     
    #1 Jarmo, Feb 13, 2023
  2. ChapmanF

    ChapmanF Senior Member

    Joined:
    Mar 30, 2008
    23,764
    15,409
    0
    Location:
    Indiana, USA
    Vehicle:
    2010 Prius
    Model:
    IV
    P0171, a lean mixture, means either too much air is getting in or not enough fuel is being injected. The high LTFT shos the ECM is going as far as it can to increase the amount of fuel injected.

    It sounds as if you have been focused more on the too-much-air possibility (though I cannot quite tell if you have directly investigated for air leaks, or only drawn conclusions about them from changes in fuel-trim numbers). Have you investigated the fuel pressure or fuel injectors yet?
     
    #2 ChapmanF, Feb 13, 2023
  3. Jarmo

    Jarmo Junior Member

    Joined:
    Jul 22, 2019
    9
    4
    0
    Location:
    Finland
    Vehicle:
    Other Hybrid
    Model:
    Touring
    Thanks,
    Maybe it does not get fuel enough... I don't have test device for fuel pressure or fuel injectors yet.
    One posibility could be fuel filter, but It located inside of fuel tank I think?
    Is it possible add pressure meter for fuel line some place?
     
    #3 Jarmo, Feb 13, 2023
  4. Jarmo

    Jarmo Junior Member

    Joined:
    Jul 22, 2019
    9
    4
    0
    Location:
    Finland
    Vehicle:
    Other Hybrid
    Model:
    Touring
    Freeze data
     

    Attached Files:

    #4 Jarmo, Feb 18, 2023
  5. Jarmo

    Jarmo Junior Member

    Joined:
    Jul 22, 2019
    9
    4
    0
    Location:
    Finland
    Vehicle:
    Other Hybrid
    Model:
    Touring
    I checked the fuel pressure. It was 26 psi only, so fuel pump assy will be next on the list. Fuel pump resistance was 7.9 ohm measured from top of tank connector. 17E25009-AE51-47F1-AFF4-35514B887BDE.jpeg 4D2C2353-3CB6-42F2-B248-AFAAD908BFFF.jpeg
     

    Attached Files:

    #5 Jarmo, Mar 2, 2023
  6. Jarmo

    Jarmo Junior Member

    Joined:
    Jul 22, 2019
    9
    4
    0
    Location:
    Finland
    Vehicle:
    Other Hybrid
    Model:
    Touring
    "New" used fuel pump assy installed and now car works... So problem solved :) Now fuel pressure is around 46psi.
     
    #6 Jarmo, Mar 8, 2023
    Mr. F likes this.
  7. mke039

    mke039 Junior Member

    Joined:
    Mar 21, 2008
    11
    0
    0
    Location:
    Massachusetts
    Vehicle:
    2006 Prius
    Same problem. How did you T into the fuel system to get pressure?
     
    #7 mke039, Oct 26, 2023
(You must log in or sign up to post here.)