suggested services for a used Gen 3

I think you have it covered, congrats and welcome!

 

Sounds well covered to me- now the next trick is to stop spending money on it and build up a cash reserve for the unexpected.

It's getting to the age where 'something' will happen, and the menu of 'somethings' on old hybrids can be pricey.

 

Did you clean the throttle body?

 

I would not be too worried about the unexpected things, I would be more worried about the three expected costly problems that will occur in the next 100k miles:
1. Head gasket failure
2. Hybrid vehicle battery failure
3. Brake booster failure.

 

I think we're talking about the same probabilities. But the way I refer to it, the timing is the unexpected element, and either way my advice to O.P. is the same: have fun, drive on and do <whatever thing you do to save for a rainy day> to be prepared.

Oh, and don't forget the air conditioner.

 

Where the air conditioner is concerned, you can take a few steps.

The thing you are most trying to avoid is the compressor working itself to death and blowing up. When that happens, they throw metal particles all throughout the system which tends to poison the next compressor... it's just a mess.

How does that happen? Usually, it is because the system has run a little low on refrigerant. Not a lot low, because there is a pressure switch to detect this and safety out the system. Just a little low.

Remember: this thing has an electric compressor whose RPM is controlled by a computer, not by the engine RPM. The automation in the system will cause the compressor to run at higher RPM over longer duty cycles to compensate for a reduced refrigerant level, and like anything else that adds wear and the limits are found faster.

So the first thing is to look for existing leaks. Dark spots on the condenser are good giveaways.

Then you can get the existing refrigerant evacuated and replace the valves and o-rings. Then pull a vacuum to test it, and if it passes, have it refilled.

That refill is a very precise procedure- you need to get that refrigerant quantity within a few grams of the target, otherwise you're right back at overworked compressor.

Where the brakes & battery are concerned? Get your money's worth out of the car before they go bad. I know of no other way.

There are ways of reconditioning the battery to stretch out their time of service, but IMO they are not worth the expense.

 

Hey,
You may not need to replace the battery. The Prolong systems should be able to help get some of your fuel economy back. Here is a link to the FAQ on their website. You might try looking at the How do I know if my hybrid battery is failing? section.

FAQ &#8211; Hybrid Automotive

It's also a good preventative maintenance tool to use on your HV battery.

Garrett

 

This is one I just leave to the dealership. Our ‘10, with build-date August ‘09, was developing so-so AC. I had the dealership service it about 5 years back, for about $160 CDN (roughly what they quoted; and of course they tried their durndest to pad the bill, it’s their nature), and no problem since.