1. Attachments are working again! Check out this thread for more details and to report any other bugs.

To prevent over heating turn off your Air conditioner for the next 10 miles !

Discussion in 'Gen 3 Prius Main Forum' started by Jasonsprite, Sep 28, 2009.

  1. Jasonsprite

    Jasonsprite Junior Member

    Joined:
    Aug 10, 2009
    74
    11
    0
    Location:
    Northridge(Los Angeles),Ca
    Vehicle:
    2019 Prius Prime
    Model:
    Prime Premium
    We see this signs on the freeways in California; I’m sure everywhere else too, when going up steep hills. In a conventional car I would turn off the Air con. But would turning off the Air con in the prius make any difference. As far as I know the Air con on the prius is Electric. So it will be draining power from the battery not the engine. When going up a hill, ICE is always on, thus continually charging the battery. yes there’s a small stress on the ICE , but not as much as in a conventional car .Is my thinking right?:)

    Jason Sprite
     
  2. a64pilot

    a64pilot Active Member

    Joined:
    Aug 3, 2008
    771
    62
    0
    Location:
    Albany Ga.
    Vehicle:
    2010 Prius
    Model:
    III
    If all things were equal it should stress the engine slightly more than a conventional car because of the conversion loses, but since I believe the Gen III Prius is a variable speed compressor maybe not. I believe the Gen III Prius also has a variable speed water pump, not sure about that though, but it is electric, so maybe it is.
    OLD cars benefited the most with the AC off, many newer cars have electric radiator fans and some of them have two fans, sometimes only one fan will run to cool the engine, but if the AC is on both fans will run. My Miata is like that. So in the Miata, running the AC may help in cooling the engine because your running two fans instead of one. YMMV of course.
    NO car should overheat ever, if the cooling system is in good shape.
    If you think you may overheat, one of the best things to do is to turn on the heat as high as it will go. Obviously the heat comes from the engine cooling system and the interior heater just became another cooling radiator for the engine.
    And no, I have never seen a sign like you have in California.
     
  3. ceric

    ceric New Member

    Joined:
    Oct 30, 2004
    1,114
    53
    0
    Location:
    Fremont, CA
    Vehicle:
    2005 Prius
    I think the sign should say
    "If your vehicle has less than 140hp, please turn off the A/C to prevent overheating."
    In my old 1991 Acura Integra (130-140hp), turning off A/C is like turning on turbo!!!
     
  4. Jasonsprite

    Jasonsprite Junior Member

    Joined:
    Aug 10, 2009
    74
    11
    0
    Location:
    Northridge(Los Angeles),Ca
    Vehicle:
    2019 Prius Prime
    Model:
    Prime Premium
    ya iv sen those signs only in CA, they only put it on a very steep Hills, where you will be climbing for more a good number of miles.
     
  5. JRitt

    JRitt Bio-Medical Equip. Tech

    Joined:
    Jul 2, 2009
    133
    10
    0
    Location:
    St Louis, Mo
    Vehicle:
    2010 Prius
    Model:
    II
    The signs are there because when climbing long grades you are dumping a lot of heat into the cooling system. That heat has to be extracted through the radiator. When it is hot the radiator has a much harder time getting rid of the heat. With the A/C running you complicate this by making the air going through the radiator hotter because the condenser coil (the radiator to get rid of the heat from the A/C unit) is mounted in front of the radiator and it heats the air more. The only was to tell if you need to turn off the A/C is by monitoring the radiators temp (no temp guage on the gen 3 Prius). If you had a scanguage you could monitor it.
     
  6. garygid

    garygid Senior Member - Blizzard Pearl

    Joined:
    Aug 23, 2009
    379
    23
    0
    Location:
    Orange County, CA
    Vehicle:
    2010 Prius
    Model:
    III
    Also, sometimes the traffic is very slow up these long grades, so the cooling is not as efficient as it is at higher speeds.

    Usually, well-maintained vehicles have few problems.

    However, one ccasionally sees overheated vehicles pulled over to the side of the highway. Usually they are older vehicles, perhaps with leaking pressure caps, and maybe using just plain water for coolant.
     
  7. creativeguy

    creativeguy Member

    Joined:
    May 21, 2009
    301
    17
    0
    Location:
    CA
    Vehicle:
    2010 Prius
    Model:
    V
    My informal polling of overheated cars on the grapevine on hot days are usually GM, Chrysler, and Ford. I've never seen a Japanese car with the hood up.
     
  8. tochatihu

    tochatihu Senior Member

    Joined:
    Apr 10, 2004
    8,972
    3,501
    0
    Location:
    Kunming Yunnan China
    Vehicle:
    2001 Prius
    I'm contrarian on this. For all Prius years, if your engine cooling loop is functioning properly it is comfortably oversized. However the HV battery can be doing big energy transfers on inclines and its air-cooling system is not necessarily oversized. That cooling system is improved when your A/C is running.

    So when the road sign says turn it off, I turn it on.
     
    1 person likes this.
  9. a64pilot

    a64pilot Active Member

    Joined:
    Aug 3, 2008
    771
    62
    0
    Location:
    Albany Ga.
    Vehicle:
    2010 Prius
    Model:
    III
    That's logical