1. Attachments are working again! Check out this thread for more details and to report any other bugs.

Access to the engine compartment from below

Discussion in 'Prime Care, Maintenance and Troubleshooting' started by zigzag, Feb 12, 2018.

  1. zigzag

    zigzag New Member

    Joined:
    Jan 18, 2018
    21
    19
    0
    Location:
    Basingstoke, UK
    Vehicle:
    2017 Prius PHV
    Model:
    Excel
    I want to get access to the lower part of the engine compartment. The reason is that I want to see if it is possible to add a new connection to the 12v Battery to run my Amateur Radio.

    I took a look this weekend and noticed that the bottom engine cover is fixed with plastic fastenings. Is it possible to remove the fastening without breaking them or should I buy another set before I start the job?

    I have a Gen4 Prius PHV (Plug-in) where 12v Battery is under the hood.
     
  2. FuelMiser

    FuelMiser Senior Member

    Joined:
    Jun 29, 2008
    1,268
    860
    0
    Location:
    Monument, CO
    Vehicle:
    2016 Prius
    Model:
    Touring
    I'd say you're likely to break one or more fasteners. The Gen 3 used these plastic fasteners on the oil filter access panel, and I've never been able to keep them from breaking and/or tearing the plastic panel itself. Gladly, Toyota used screws on the Gen 4 oil filter access!
     
  3. Prodigyplace

    Prodigyplace Senior Member

    Joined:
    Nov 1, 2016
    11,696
    11,317
    0
    Location:
    Central Virginia
    Vehicle:
    2017 Prius
    Model:
    Two
    I would expect there would be runner plugs through the firewall from the engine compartment to inside the car.
    @Elektroingenieur may know. I know @sfv41901 has worked on Gen 4 and Prime should be similar.
     
  4. Mendel Leisk

    Mendel Leisk Senior Member

    Joined:
    Oct 17, 2010
    54,676
    38,219
    80
    Location:
    Greater Vancouver, British Columbia, Canada
    Vehicle:
    2010 Prius
    Model:
    Touring
    I use one of these the most, when removing the plastic fasteners (on our 3rd gen):

    upload_2018-2-12_7-54-12.png

    A paint can opener with hooked tip. It's relatively easy to hook under the cap and pry up. I also occasionally use a slim bladed screw driver, and once in a while a traditional pry tool, the kind that cup around both sides of the plastic fastener collar:

    upload_2018-2-12_7-57-8.png

    I've done maybe 14 (DIY) six monthly oil changes on our 3rd gen, taking the engine under panel completely off each time, and at least a half dozen more instances I've taken it off. I've got a few spares of the plastic fasteners, and while I can't really recall, I believe I've had one break, at most.

    The main issue: grit can get into the internals, which can cause them to jam when you try to pry up the central post. If this happens just take it real easy, pry both sides of the center cap, use caution.

    With my 6 monthly removal, I always wash the fasteners out with hot/soapy water, basically returning them to new condition. This seems to me the main factor in maintaining them.

    With your fourth gen, there may be more than one fastener style. Assuming that, I would see if you can get a printout with the parts numbers, which go where.
     
    Raytheeagle likes this.
  5. Prodigyplace

    Prodigyplace Senior Member

    Joined:
    Nov 1, 2016
    11,696
    11,317
    0
    Location:
    Central Virginia
    Vehicle:
    2017 Prius
    Model:
    Two
    Perhaps @Elektroingenieur could share a graphic of the fastener placement on the Prime, if there is more than one fastener type.
     
    Mendel Leisk likes this.
  6. zigzag

    zigzag New Member

    Joined:
    Jan 18, 2018
    21
    19
    0
    Location:
    Basingstoke, UK
    Vehicle:
    2017 Prius PHV
    Model:
    Excel
    Thank you
     
    Raytheeagle and Mendel Leisk like this.
  7. Elektroingenieur

    Elektroingenieur Senior Member

    Joined:
    Jan 8, 2017
    2,515
    3,253
    9
    Location:
    California
    Vehicle:
    2016 Prius
    Model:
    Three Touring
    I would, but I haven’t found a detailed illustration of the underside of the Prius PHV. The Repair Manual just says, “Remove the 10 clips, 4 bolts and No. 1 engine under cover assembly,” without showing the fastener locations. For reinstallation, the four bolts are torqued to 7.5 N·m {76 kgf·cm, 66 in·lbf}.

    In parts catalog Figure 51-02, Suspension Crossmember & Under Cover, the second illustration (enlarged view) shows the No. 1 engine under cover assembly (51410-47070) and its ten plastic clips (90467-07220) and four bolts (90119-06A13). These Toyota part numbers are common to RHD and LHD vehicles.

    If you’re careful, you can sometimes remove and reinstall the plastic clips without damage. I’d suggest buying a few spares, though, especially if you might need to remove the cover assembly more than once.

    If @zigzag is considering a new connection to the auxiliary (12-volt) battery, he might also be interested in my posting about the battery state sensor; I believe the general arrangement on the Prius PHV is similar, though some of the reference designations are different.
     
    zigzag and Prodigyplace like this.
  8. zigzag

    zigzag New Member

    Joined:
    Jan 18, 2018
    21
    19
    0
    Location:
    Basingstoke, UK
    Vehicle:
    2017 Prius PHV
    Model:
    Excel
    Thank you @Elektroingenieur that's all really useful, especially the information about the battery sensor.
     
    Elektroingenieur likes this.
  9. vvillovv

    vvillovv Senior Member

    Joined:
    Mar 19, 2013
    3,529
    1,242
    1
    Location:
    NY
    Vehicle:
    2017 Prius Prime
    Model:
    Prime Plus
    I took a short look a week or two ago with the car on the ground, how to drop the panel and I noticed
    ( mostly felt around ) both bolts and pins/clips.
    From experience, the longer the clips stay in the car the easier it is the break them when trying to remove them.
    If the pins exercised and lubed before replacing they are easier to remove the next time,
    no matter what condition they are in when replaced.
    I'm still not sure which lube is best, but any oil or silicon based lube make removing them easier than reinstalling the clips dry
    pin-pliers.jpg Push Pin Pliers
    I got one of these for $10 harbor freight, but only because I had to remove 40 or so that had been in for years
    and I wouldn't recommend them for newer clips. But they will get pesky ones out even if they have to be broken out.
     
    zigzag likes this.